MARINE CORPS BASE QUANTICO, Va. —
A harvesting effort by Program Executive Officer Land Systems and Marine Corps Systems Command could save the Corps millions and make one of its newest vehicles more survivable.
The Gunner’s Protection Kit, managed by Infantry Weapons within MCSC’s Portfolio Manager Ground Combat Equipment Systems, is currently installed on High Mobility Multipurpose Wheeled Vehicles. As a cost-savings measure, the kits will be removed from HMMWVs and installed on Joint Light Tactical Vehicles as they are fielded to the fleet next year. Using harvested parts instead of buying new potentially saves the Corps more than $100 million.
Logisticians and equipment specialists from Marine Corps Systems Command and Program Executive Officer Land Systems install a Marine Corps Transparent Armor Gun Shield on a Joint Light Tactical Vehicle May 1. The installation is part of a cost-savings plan to harvest Gunner’s Protection Kits and other equipment from older High Mobility Multipurpose Wheeled Vehicles and increase the JLTV’s survivability. (U.S. Marine Corps photo by Kristen Murphy)
“The harvesting strategy was developed by the JLTV Joint Program Office in 2012 as part of our efforts to meet affordability metrics for the program,” said Andy Rodgers, program manager for Light Tactical Vehicles in Program Executive Officer Land Systems. “Our collaboration with [Marine Corps Systems Command’s] Program Manager Infantry Weapons is key to that strategy.”
In the spring, logisticians and other program personnel from Infantry Weapons conducted a Proof of Principle, or PoP, going step by step through the process of removing a Marine Corps Transparent Armor Gun Shield—part of the GPK family of systems—from a HMMWV and placing it on a JLTV. The MCTAGS will be installed on the Heavy Guns Carrier JLTV variant.
Marines from 1st Battalion, 7th Marines prepare to load Joint Light Tactical Vehicles onto Landing Craft Utility boats in preparation for a JLTV Multiservice Operational Test and Evaluation amphibious landing March 2, at Camp Pendleton, California. As part of a cost-savings plan, the Marine Corps will harvest Gunner’s Protection Kits and other equipment from older High Mobility Multipurpose Wheeled Vehicles and install them on JLTVs to increase the new vehicles’ survivability. (U.S. Marine Corps courtesy photo)
The PoP will help the program office develop, verify and publish a modification instruction to guide the Corps through the installation process, said Kevin Marion, a logistics management specialist in Infantry Weapons.
“The PoP was successful,” Marion said. “We started with existing [instruction] manuals for the MCTAGS, and then added steps for putting it on the new vehicle. In addition to documenting the steps, it also gave us a chance to identify any parts that can’t be reused because the degree of serviceability is questionable.”
The JLTV program office has completed similar PoP efforts with the Improved TOW GPK, or I-TGPK, which will be installed on the Close Combat Weapons Carrier variant of the JLTV. The CCWC can be armed with TOW—tube-launched, optically tracked, wire-guided—missiles.
The JLTV is an Army-led light tactical vehicle program. It will partially replace the Army and Marine Corps HMMWV fleet, providing a more survivable vehicle, and closing an existing gap in payload, performance and protection. The JLTV comes in four variants with payloads ranging from 3,500 to 5,100 pounds of cargo, and can go more than 70 miles per hour as well as traverse over arduous terrain.
Although only two variants will be equipped with the MCTAGS or I-TGPK, all JLTVs will contain harvested radios, antennas and other communications equipment from HMMWVs.
“It’s our responsibility as MCSC to be good stewards of taxpayer money, so if we have equipment that is in good condition, we should go ahead and use it,” Marion said.
An advantage to Marines is the tactics, techniques and procedures will remain largely unchanged for the harvested equipment, so they already know how to operate it, Rodgers said.
The HMMWVs will be demilitarized and traded through the Equipment Exchange Program. This program enables the organization to work with commercial vendors who can sell or use the vehicles as they see fit.
“The exchange program is no cost to the government, and no money changes hands,” Rodgers said. “In exchange, the vendor buys equipment we may need like MCTAG covers or ring mounts for the JLTV, and they ship it wherever we need it.”
Once vehicle fielding begins next year, Marine Corps field service representatives will execute the harvesting plan for the units that receive them, Rodgers said. This is part of the program’s “total package fielding” plan.
“As we field the JLTV, we’ll collect the HMMWV, harvest the parts, install them and then return the new vehicles [to the units],” Rodgers said.
Fielding for the JLTV will begin in spring 2019 to the Marine Corps School of Infantry-West at Camp Pendleton, California; School of Infantry-East at Camp Lejeune, North Carolina; The Basic School at Marine Corps Base Quantico, Virginia; and Motor Transport Maintenance Instructional Company at Camp Johnson, North Carolina. Fielding to the operating forces will begin in the summer of 2019. In all, the Army plans to purchase 49,000 JLTVs and the Marine Corps will purchase 9,091.
By Monique Randolph, MCSC Office of Public Affairs and Communication | Marine Corps Systems Command
The government is going to salvage useable parts before selling equipment for pennies on the dollar? Radical concept! I thought they usually sold the parts for pennies on the dollar and then repurchased them at retail.